2009_Supplement_V70_(08-)_XC70_(08-)_S80_(07-)_wiring_diagram.pdf
(
21952 KB
)
Pobierz
VOLVO V70 (08-), XC70 (08-) & S80 (07-)
WIRING DIAGRAM
2009
SUPPLEMENT
TP 39138202 LATE DESIGN
Vehicles with SRS (Airbag)/SIPS bag/
IC (Inflatable curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
Is the vehicle equipped with SRS/SIPS bag/IC?
Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering
wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the
dashboard above the glove compartment. SRS vehicles from 1993 and onward also have
explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and
onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with
IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).
General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never fit accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VIDA.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VIDA.
• Install no accessories in the areas between the A and B-posts, the B and C-posts, and the C
and D-posts.
Test terminal
Fuse in cargo compartment auxiliary fuse box
Changes implemented up to and including May 2008
Any changes made to the vehicle after this date are not included in the manual. If necessary,
refer to service bulletins.
Volvo models are sold in versions adapted for different markets. These adaptations depend
on factors such as legal requirements, taxation, and market demands.
This manual may therefore include illustrations and text that do not apply to the vehicles in
your country.
Order number
TP 39138202
Can be ordered from Technical Information Shop (TIS)
at www.volvocarstechinfo.ford.com/vss
We retain the right to make modifications.
© Volvo Car Corporation
Table of Contents
Explanations .................................................................. 4
How to use the wiring diagrams 1:2............................... 5
Electrical distribution 1:2 ................................................ 7
Group 23 Fuel system
Engine management system 5-Cyl. Diesel
EURO5 1:3 .................................................................. 47
Fuses
Engine compartment electrical center F1-F7.................. 9
Engine compartment distribution box F9-F24............... 10
Engine compartment distribution box F25-F30............. 11
Engine compartment distribution box F31-F37............. 12
Engine compartment distribution box F38 .................... 13
Engine compartment electrical center F39-F44............ 14
Central Electronic Module (CEM) F1 - F11................... 15
Central Electronic Module (CEM) F13 - F19................. 16
Central Electronic Module (CEM) F20 - F28................. 17
Rear electrical center FA1-FA12 .................................. 18
Distribution box in cargo compartment FB1-FB12........ 19
Rear electrical center FD1-FD7 .................................... 20
Battery PF1-PF2 ........................................................... 21
Group 26 Cooling system
Cooling fan 5-Cyl. Diesel EURO5 ................................ 50
Group 27 Engine controls
Cruise control 5-Cyl. Diesel EURO5 ............................. 51
Group 32 Alternator and voltage regulator
Power supply ............................................................... 52
Group 33 Starting system
Starting system ............................................................ 53
Group 35 Lighting
Interior lighting, LHD 1:2 .............................................. 54
Interior lighting, RHD 1:2.............................................. 56
Relays
Relays in the engine compartment R2......................... 22
Relays in the engine compartment R8-R9................... 23
Relays in the engine compartment R10-R13............... 24
Cargo compartment ..................................................... 25
Distribution box in cargo compartment RA1-RD1........ 26
Central Electronic Module (CEM) ................................ 27
Group 36 Additional electrical equipment
Keyless vehicle 1:2 ...................................................... 58
Group 39 Other
Audio Premium 1:3 ...................................................... 60
Ground connections
Overview...................................................................... 28
31/2 - 31/6 ................................................................... 29
31/7 - 31/10 ................................................................. 30
31/15 - 31/47 ............................................................... 31
31/66 - 31/83 ............................................................... 32
31/84 - 31/INFOT......................................................... 33
Group 43 Transmission
Transmission M66........................................................ 63
Automatic transmission MPS6 ..................................... 64
Climate control system 5-Cyl. Diesel EURO5 1:2........ 65
Connectors................................................. 67
Control modules
Overview locations....................................................... 34
Overview designations................................................. 35
Central Electronic Module (CEM) 1:3 .......................... 36
Data communication high speed CAN......................... 39
Data communication high speed CAN, 4-Cyl. ............. 40
Data communication intermediate speed
CAN, LHD .................................................................... 41
Data communication intermediate speed
CAN, RHD ................................................................... 42
Data communication, LIN 1:2 ...................................... 43
Data communication MOST......................................... 45
Steering Wheel Module (SWM) ................................... 46
Branching points .......................................72
Cable harness routing in vehicle
Harness engine, Diesel................................................. 79
Tunnel harness ............................................................. 79
Component illustrations ............................80
Index ..........................................................103
List of components 1:3 ............................104
TP39138202 V70(08-), XC70(08-) & S80(07-) 2009 Supplement
3
Explanations
Abbreviations
Groups
Group 23
Other
ACC = Adaptive Cruise Control
Ag = Silver plated
Au = Gold plated
AUTO = Automatic transmission
BLIS = Blind spot information system
CAN = CAN communication
DPY = Display
ECC = Electronic climate control system
ETA = Engine throttle body
EXC = Exclusive
GDL = Gas discharge lamp
HISPEED = High speed data bus
IR = Infrared sensor
LIN = LIN communication
LH = Left-hand side
LHD = Left-hand drive
MAN = Manual transmission
MEMORY = Memory driver’s seat
MIDSPEED = Midspeed data bus
MMS
= Fuel system
Group 26
= Cooling system
Group 27
= Engine controls
Group 32
= Alternator and voltage regulator
Group 33
= Starting system
Group 35
= Lighting
Group 36
= Additional electrical equipment
Group 37
= Wiring and fuses
Group 38
= Instruments
Group 39
= Other
Group 43
= Transmission
Group 59
= Brake system
Group 64
= Steering
Group 83
= Doors and openings
Group 84
= Exterior decorative elements, etc.
Group 85
= Interior equipment
Group 87
= Climate control system
Group 88
= Internal equipment
Ignition switch symbols
X
= Mass Movement Sensor
PETROL
= Gasoline
= Accessories (audio position)
RH
= Right-hand side
S
= Powered upon insertion of key
RHD
= Right-hand drive
15
= Contact remains connected during
start
SCR
= Screened
SRS
= Airbag
15l
= Contact is broken while starting
T
= Turbocharged engine
30
= Constant power from the battery
W/O
= Without
50
= Start
2WD
= Two-wheel drive
4CYL, I4
= 4-cylinder engine
Countries/Markets
A
5CYL, I5
= 5-cylinder engine
= Austria
6CYL, I6
= 6-cylinder engine
AUS
= Australia
8CYL, V8
= 8-cylinder engine
B
= Belgium
CDN
= Canada
Colors
BK, SB
CH
= Switzerland
= Black
D
= Germany
BN
= Brown
DK
= Denmark
BU, BL
= Blue
E
= Spain
GN
= Green
EU/OS
= Markets outside USA and Canada
GY, GR
= Gray
FIN
= Finland
LGN
= Light Green
GB
= Great Britain
NL
= Natural
ISR
= Israel
OG, OR
= Orange
J
= Japan
PK, P
= Pink
KOR
= Korea
RD, R
= Red
N
= Norway
VT, VO
= Violet
NL
= Netherlands
WH, W
= White
S
= Sweden
YE, Y
= Yellow
USA
= United States of America
WEU
= Western Europe
TP39138202 V70(08-), XC70(08-) & S80(07-) 2009 Supplement
4
How to use the wiring diagrams 1:2
The descriptions below apply in general
to all wiring diagram manuals, although
not all sections are necessarily con-
tained in this manual.
A. Component designation
Every component has a component designation that
consists of two parts.
B. Branching points
The wiring diagrams contain numbered branching
points, for example 73/5035.
The first part is a type number that describes the
type of component in question, for example 3/xx.
This manual contains a section with a list of branch-
ing points. This list shows all the components that
are connected to each branching point.
The second part of the designation is a serial num-
ber, e.g. x/2.
The location of the branching points is shown in the
"Cable harness routing in vehicle" section.
Together, this constitutes a component designation,
e.g. 3/2.
C. Connectors
Connectors provide a bridge between two cable har-
nesses and are described in the "Connectors" sec-
tion.
At the end of the manual is a list of components,
where, with the help of the component designation,
you can read off the name of the component, for
example, 3/2 = light switch.
D. Electrical distribution
Operation of the fuses and relays is shown in the
"Electrical distribution" section.
List of type numbers
The list shows which type of component that respec-
tive type numbers refer to, for example, 3/x = switch,
6/x = electric motor, etc.
E. Data communication
Today’s cars contain CAN, LIN and MOST networks
that transfer information. Connections to these net-
works are not shown in their entirety in the respec-
tive wiring diagram. Complete information on CAN,
LIN and MOST communication is found in the sec-
tion "Control modules".
1
Battery
2
elay
3
Switch
4
Control module
5
Driver information module
6
Electric motor
F. Abbreviations
A number of different abbreviations are used in the
manual. These are explained in the section "Abbre-
viations".
7
ensor
8
Actuator
9
Heating element
10
Light
11
Fuse
15
Electrical distribution rail/box
G. Component location
The end of the manual contains a section that
describes component appearance and location in
numerical order.
16
Audio
17
Service/diagnostics
18
Contact reel
19
Meter
20
Ignition component/shunt
27
Optics
31
Ground connection
73
Branching point
74
Connector
TP39138202 V70(08-), XC70(08-) & S80(07-) 2009 Supplement
5
Plik z chomika:
zgielek
Inne pliki z tego folderu:
1994_850_wiring_diagram.pdf
(35362 KB)
1994_940_wiring_diagram.pdf
(26858 KB)
1994_960_wiring_diagram.pdf
(31545 KB)
1995_850_wiring_diagram.pdf
(41605 KB)
1995_940_wiring_diagram.pdf
(51957 KB)
Inne foldery tego chomika:
African Roots
AirBagServiceTool 3.9
AirBagServiceTool 3.9(1)
Desert Blues 3 (Entre_Dunes_Et_Savanes)
Dokumenty
Zgłoś jeśli
naruszono regulamin